MATERIAL SAFETY DATA SHEET

 

Wausau Chemical Corporation, 2001 N. River Drive, Wausau, WI 54403

                                                                             Last Revision:                          January 8, 2004

HMIS Hazard 4 – Extreme                  Health              3 3 – High                       Fire                  0 2 – Moderate               Reactivity         0 1 – Slight                      Other 0 - Least

Emergency       CHEMTREC              800-424-9300

Phones:            Wausau Chemical         715-842-2285

SECTION 1 - MATERIAL IDENTIFICATION

 

 

 

NAME:                        FEED LINE CLEANER

SYNONYMS:             Chlorinated, alkaline cleaner

SECTION 2  - HAZARDOUS INGREDIENTS

 

 

 

HAZARDOUS CHEMICAL               CAS #             PERCENT       PEL/TWA        SARA III, SEC 313    

Sodium Hydroxide                                1310-73-2       15%                     2 mg/m3                   NO

Sodium Hypochlorite                            7681-52-9       3.5%                     NE                          NO

 

 

SECTION 3 – CHEMICAL AND PHYSICAL PROPERTIES

 

 

 

Appearance:           Clear, light yellow liquid                  Boiling Point (^oF):                                 over 212 ^oF

Odor:                     Slight chlorine odor             Melting Point (^oF):                                NA

pH:                          >13.0                                            Specific Gravity (H₂O=1):                     1.250

Water solubility:      Complete                                       Vapor Pressure, mm Hg, ^oF                  NA

Vapor Density (air=1)   :           NE                               Volatile Organic (VOC) content:           None

Evaporation Rate (Butyl Acetate = 1)                NE

 

SECTION 4 – FIRE AND EXPLOSION HAZARDS

 

 

Flash Point (Method):               None                Explosive Limits: Lower            None    Upper              None   

Flammable Limits:                     None                Auto Ignition Temperature:        None

Extinguishing Media:                 Not applicable

 

Special Fire Fighting Procedures and Hazards:  None

 

Unusual Fire & Explosion Hazards:                               None known.

 

SECTION 5 – REACTIVITY INFORMATION

 

 

Stable:    X  Unstable:               Hazardous Polymerization:   Occurs:                 Does not Occur:           X

 

Conditions to Avoid:                 Avoid contact with acids. Poisonous chlorine gas will be liberated

 

Materials to Avoid:                   Acids.

 

Decomposition Products:          Chlorine gas.

 

Feed Line Cleaner                                                                                                                             Page 2

SECTION 6 – HEALTH HAZARDS – PROTECTIVE MEASURES  – FIRST AID

 

 

Carcinogen:      No

 

EYES:              Extremely corrosive to the eyes with possible severe irritation and burns. Flush thoroughly with water for 15 minutes. Get medical attention if symptoms or irritation persists. Use chemical goggles while handling this material.

 

SKIN:              Extremely corrosive to the skin. Prolonged or repeated contact can cause severe irritation and burns. Wash thoroughly with water for 15 minutes. Use neoprene apron and gloves while handling this material.

 

INHALATION:           Mist or vapors can cause irritation or damage to the respiratory system.

 

INGESTION:              Extremely corrosive to the mouth, esophagus and mucous membranes. Drink large amounts of water or milk. DO NOT induce vomiting. Get immediate medical attention.

 

IN ALL CASES:          GET PROMPT MEDICAL ATTENTION IF ADVERSE EFFECTS PERSIST

 

PRIMARY ROUTES OF ENTRY:      Skin, eyes, inhalation, ingestion.

 

HYGIENE:      Wash hands and face before eating or drinking. Wash soiled clothing before wearing again if contact occurs.

SECTION 7 – PRECAUTIONS FOR SAFE HANDLING, STORAGE AND USE

 

 

 

SPILLS AND LEAKS:            Contain to prevent loss to the environment. Collect excess material. Flush         

residual material to a sanitary sewer.

 

STORAGE AND HANDLING:           Keep containers tightly closed. Store at ambient temperatures and out of sunlight.

 

WASTE DISPOSAL:              Follow recommendations of local, state and federal regulations.

 

EMPTY CONTAINERS:        Rinse thoroughly with water. Send to a recycling center or return to Wausau Chemical Corporation.

SECTION 8 – REGULATORY INFORMATION

 

 

 

DOT SHIPPING DESCRIPTION:      Corrosive liquid, basic, inorganic, N.O.S., (Contains Sodium                                                                 Hydroxide and Sodium Hypochlorite), 8, UN3266, PG II

 

LABEL REQUIRED:               Corrosive

 

The information contained herein is given in good faith, but no warranty, representation, inducement or license of any kind is made, except that the information is accurate to the best of Wausau Chemical Corporation’s knowledge, or is obtained from sources believed by Wausau Chemical Corporation to be reliable and accurate. Wausau Chemical Corporation does not assume any legal responsibility for use or reliance upon the information being furnished. Customers are encouraged to conduct their own tests. Before using any product, read the container label directions as well as the Material Safety Data Sheet.

 

 

 

 

 

 

ND – Not Determined              NA – Not Applicable               NE – Not Established