MATERIAL SAFETY DATA SHEET

 

Wausau Chemical Corporation, 2001 N. River Drive, Wausau, WI 54403

                                                                             Last Revision:               January 27, 2004

HMIS Hazard 4 – Extreme                  Health              2 3 – High                       Fire                  2 2 – Moderate               Reactivity         0 1 – Slight                      Other 0 - Least

Emergency       CHEMTREC               800-424-9300

Phones:            Wausau Chemical         715-842-2285

SECTION 1 - MATERIAL IDENTIFICATION

 

 

 

NAME:                        GLYCOL ETHER PNP

FORMULA:               

SYNONYMS:             Propylene Glycol n-Propyl Ether, 2-Propanol, 1-Propoxy; N-Propoxy Propanol

MANUFACTURER:   Dow Chemical Company; Eastman Chemical Corp; ARCO Chemical Company

SECTION 2  - HAZARDOUS INGREDIENTS

 

 

 

HAZARDOUS CHEMICAL               CAS #             PERCENT       PEL/TWA        SARA III, SEC 313    

Propylene glycol n-propyl ether 001569-01-3       99%             NE                               NO

 

SECTION 3 – CHEMICAL AND PHYSICAL PROPERTIES

 

 

 

Appearance:                 Clear, colorless liquid                Boiling Point (^oF):                                 302^oF

Odor:                           Slight ether                               Freezing Point (^oF):                               ND

pH:                               NA                                          Specific Gravity (H₂O=1 @ 70^oF):       0.885

Water solubility:            Infinite                                      Vapor Pressure, mm Hg, 20^oC: 1.7

Vapor Density (air=1):  ND                              Volatile Organic (VOC) content:           100%

Evaporation Rate (Butyl Acetate = 1)                ND

SECTION 4 – FIRE AND EXPLOSION HAZARDS

 

 

Flash Point (Method):     119^oF (T.C.C.)          Flammability Limits: Lower       ND      Upper  ND

Auto Ignition Temperature:        500 ^oF

Extinguishing Media:                 Water spray, dry chemical, carbon dioxide.

 

Special Fire Fighting Procedures and Hazards:  Wear chemical protective clothing and positive pressure self-contained breathing apparatus. Approach upwind to avoid toxic vapors. Avoid applying a direct water stream.

Unusual Fire & Explosion Hazards:       When heated above flash point, product releases unidentified toxic vapors in addition to carbon monoxide and carbon dioxide.

 

Unusual Fire & Explosion Hazards:      

SECTION 5 – REACTIVITY INFORMATION

 

Stable:    X  Unstable:               Hazardous Polymerization:   Occurs:                 Does not Occur:           X

 

Conditions to Avoid:     Avoid static discharge. Flammable vapors can be released at elevated temperatures.

 

Materials to Avoid:       Oxidizing materials.

 

Decomposition Products:          Combustion products of carbon dioxide and carbon monoxide and other unknown gases at high temperatures.

 

Glycol Ether PNP                                                                                                                               Page 2

SECTION 6 – HEALTH HAZARDS – PROTECTIVE MEASURES  – FIRST AID

 

 

Carcinogen:      No

 

EYES:              May cause irritation. Vapors may cause corneal injury. Use chemical goggles when handling this product. In the event of contact flush with water for 15 minutes. Get medical attention if symptoms develop.

 

SKIN:              Low hazard for normal industrial handling. Repeated or prolonged exposure may cause drying or flaking of the skin. Use neoprene or rubber gloves and apron. In the event of contact wash thoroughly with soap and water. Get medical attention if symptoms develop.

 

INHALATION:           Low hazard for usual industrial handling. If symptoms occur, remove to fresh air. Get medical attention if necessary.

 

INGESTION:              Low hazard for usual industrial handling. If symptoms occur, get medical advise.

 

IN ALL CASES:          GET PROMPT MEDICAL ATTENTION IF ADVERSE EFFECTS PERSIST

 

PRIMARY ROUTES OF ENTRY:      Skin, eyes, inhalation, ingestion.

 

HYGIENE:      Wash hands and face before eating or drinking. Wash soiled clothing before wearing again if contact occurs.

SECTION 7 – PRECAUTIONS FOR SAFE HANDLING, STORAGE AND USE

 

 

 

SPILLS AND LEAKS:            Contain to prevent loss to the environment. Absorb with vermiculite or inert material. Collect excess material. Prevent runoff from entering waterways.

 

STORAGE AND HANDLING:           Keep containers tightly closed. Store away from heat and light and ignition sources. Good ventilation is required for use of this material. Use an approved respirator if fumes are excessive.

WASTE DISPOSAL:              Follow recommendations of local, state and federal regulations.

 

EMPTY CONTAINERS:        Replace and firmly tighten closures. Send to a recycling center or return to Wausau Chemical Corporation.

SECTION 8 – REGULATORY INFORMATION

 

 

 

DOT SHIPPING DESCRIPTION:      Combustible Liquid, N.O.S., (Propyoxypropanol), Combustible                                                                        Liquid, NA1993 PG III

 

LABEL REQUIRED                            None

 

The information contained herein is given in good faith, but no warranty, representation, inducement or license of any kind is made, except that the information is accurate to the best of Wausau Chemical Corporation’s knowledge, or is obtained from sources believed by Wausau Chemical Corporation to be reliable and accurate. Wausau Chemical Corporation does not assume any legal responsibility for use or reliance upon the information being furnished. Customers are encouraged to conduct their own tests. Before using any product, read the container label directions as well as the Material Safety Data Sheet.

 

 

 

 

 

 

ND – Not Determined              NA – Not Applicable               NE – Not Established