MATERIAL SAFETY DATA SHEET

 

Wausau Chemical Corporation, 2001 N. River Drive, Wausau, WI 54403

                                                                             Last Revision:               January 28, 2004

HMIS Hazard 4 – Extreme                  Health              2 3 – High                       Fire                  3 2 – Moderate               Reactivity         0 1 – Slight                      Other 0 - Least

Emergency       CHEMTREC               800-424-9300

Phones:            Wausau Chemical         715-842-2285

SECTION 1 - MATERIAL IDENTIFICATION

 

 

 

NAME:            OXIDIZED OIL SPOTTER

SYNONYMS:            

SECTION 2  - HAZARDOUS INGREDIENTS

 

 

 

HAZARDOUS CHEMICAL               CAS #             PERCENT       PEL/TWA        SARA III, SEC 313    

N-Butyl Alcohol                                   71-36-3                                   50 ppm                        NO

Potassium Hydroxide                            1310-58-3                               2 mg/m³                        NO

 

 

SECTION 3 – CHEMICAL AND PHYSICAL PROPERTIES

 

 

 

Appearance:           Clear colorless liquid                       Boiling Point (^oF):                                 244 ^oF

Odor:                     Alcohol odor                                  Freezing Point (^oF):                               ND

pH:                         >10                                                Specific Gravity (H₂O=1 @ 70^oF):       0.840

Water solubility:            Complete                                 Vapor Pressure, mm Hg, 20^oC:             ND

Vapor Density (air=1): ND                              Volatile Organic (VOC) content:           99%

Evaporation Rate (Butyl Acetate = 1)    ND

 

SECTION 4 – FIRE AND EXPLOSION HAZARDS

 

 

Flash Point (Method):               95 ^oF                Explosive Limits: Lower            1.4 ^oF   Upper  11.2 ^oF

Flammable Limits:                     ND                  Auto Ignition Temperature:        ND

Extinguishing Media:                 Water spray, dry chemical, carbon dioxide or alcohol resistant foam.

 

Special Fire Fighting Procedures and Hazards:  Wear chemical protective clothing and positive pressure self-contained breathing apparatus. Approach upwind to avoid toxic vapors.  Flammable so vapors can travel large distances to an ignition source where they can ignite or explode.  Heavier than air so can accumulate in low spots.

 

Unusual Fire & Explosion Hazards:                               None known.

 

SECTION 5 – REACTIVITY INFORMATION

 

 

Stable:    X  Unstable:               Hazardous Polymerization:   Occurs:                 Does not Occur:           X

 

Conditions to Avoid:                 Ignition sources.

 

Materials to Avoid:                   Strong acid or bases, oxidizers, halogens.

 

Decomposition Products:          Carbon dioxide carbon monoxide

Oxidized Oil Spotter                                                                                                                          Page 2

SECTION 6 – HEALTH HAZARDS – PROTECTIVE MEASURES  – FIRST AID

 

 

Carcinogen:      No

 

EYES:              Mild eye irritant. Use chemical goggles when handling this product. In the event of contact flush with water for 15 minutes. Get medical attention if symptoms develop.

 

SKIN:              Can cause skin irritation on repeated or prolonged contact. Use neoprene or rubber gloves and apron when handling this product. In the event of contact wash with water for 15 minutes. Get medical attention if symptoms develop.

 

INHALATION:           Excessive concentrations of mist or vapors can cause irritation of the respiratory system. High vapor concentrations can cause drowsiness. Provide adequate ventilation.

 

INGESTION:              Irritation to the mouth, esophagus and mucous membranes. Get immediate medical attention.

 

IN ALL CASES:          GET PROMPT MEDICAL ATTENTION IF ADVERSE EFFECTS PERSIST

 

PRIMARY ROUTES OF ENTRY:      Skin, eyes, inhalation, ingestion.

 

HYGIENE:      Wash hands and face before eating or drinking. Wash soiled clothing before wearing again if contact occurs.

SECTION 7 – PRECAUTIONS FOR SAFE HANDLING, STORAGE AND USE

 

 

 

SPILLS AND LEAKS:            Contain to prevent loss to the environment. Collect excess material. Flush residual material to a sanitary sewer.

 

STORAGE AND HANDLING:           Keep containers tightly closed. Store at ambient temperatures.

 

WASTE DISPOSAL:              Follow recommendations of local, state and federal regulations.

 

EMPTY CONTAINERS:        Replace and firmly tighten closures. Send to a recycling center or return to Wausau Chemical Corporation.

 

SECTION 8 – REGULATORY INFORMATION

 

 

 

DOT SHIPPING DESCRIPTION:      Flammable Liquids, N.O.S., (N-Butyl Alcohol), 3, UN2924, PG III

 

LABEL REQUIRED                            Flammable

 

The information contained herein is given in good faith, but no warranty, representation, inducement or license of any kind is made, except that the information is accurate to the best of Wausau Chemical Corporation’s knowledge, or is obtained from sources believed by Wausau Chemical Corporation to be reliable and accurate. Wausau Chemical Corporation does not assume any legal responsibility for use or reliance upon the information being furnished. Customers are encouraged to conduct their own tests. Before using any product, read the container label directions as well as the Material Safety Data Sheet.

 

 

 

 

 

 

ND – Not Determined              NA – Not Applicable               NE – Not Established