MATERIAL SAFETY DATA SHEET

 

Wausau Chemical Corporation, 2001 N. River Drive, Wausau, WI 54403

                                                                             Last Revision:               February 11, 2004

HMIS Hazard 4 – Extreme                  Health              2 3 – High                       Fire                  2 2 – Moderate               Reactivity         0 1 – Slight                      Other 0 - Least

Emergency       CHEMTREC               800-424-9300

Phones:            Wausau Chemical         715-842-2285

SECTION 1 - MATERIAL IDENTIFICATION

 

 

 

NAME:                        SOLV D

SYNONYMS:            

SECTION 2  - HAZARDOUS INGREDIENTS

 

 

 

HAZARDOUS CHEMICAL               CAS #             PERCENT       PEL/TWA        SARA III, SEC 313    

PETROLEUM HYDROCARBON      64742-48-9                             500 ppm                      NO

AROMATIC 100                                64742-95-6                             150 ppm                      NO

XYLENE                                             1330-20-7           <2%             150 ppm                      YES

CUMENE                                            98-82-8               <1%               50 ppm                      YES

1,2,4-TRIMETHYLBENZENE           25551-13-7         ~15%             25 ppm                      YES

SECTION 3 – CHEMICAL AND PHYSICAL PROPERTIES

 

 

 

Appearance:           Clear, colorless liquid                      Boiling Point (^oF):                                 313-418 ^oF

Odor:                     Characteristic petroleum                 Freezing Point (^oF):                               ND

pH:                         NA                                                            Specific Gravity (H₂O=1 @ 70^oF):       0.853

Water solubility:            Negligible                                 Vapor Pressure, mm Hg, 20^oC: ND

Vapor Density (air=1):  Heavier                        Volatile Organic (VOC) content:           100%

Evaporation Rate (Butyl Acetate = 1)                ND

 

SECTION 4 – FIRE AND EXPLOSION HAZARDS

 

 

Flash Point (Method):   >104 ^oF                      Explosive Limits: Lower            1.0%    Upper              6.0%   

Flammable Limits:                     ND                  Auto Ignition Temperature:        ND

Extinguishing Media:                 Foam, carbon dioxide, dry chemical

 

Special Fire Fighting Procedures and Hazards:  Self contained breathing apparatus is recommended. Water is not a suitable extinguishing media but good for keeping containers cool.

Unusual Fire & Explosion Hazards:       Vapors are heavier than air and can travel along the ground and gather in low areas which can be ignited by ignition sources such as pilot lights. Overheated containers can burst due to pressure buildup.

 

SECTION 5 – REACTIVITY INFORMATION

 

 

Stable:    X  Unstable:               Hazardous Polymerization:   Occurs:                 Does not Occur:           X

 

Conditions to Avoid:                 None known. Keep away from heat or ignition sources.

 

Materials to Avoid:                   Strong oxidizing agents.

 

Decomposition Products:          Forms smoke, carbon monoxide and carbon dioxide at high heat.

Solv D                                                                                                                                                 Page 2

SECTION 6 – HEALTH HAZARDS – PROTECTIVE MEASURES  – FIRST AID

 

 

Carcinogen:      No

 

EYES:              Mild eye irritant. Eye protection is recommended when handling this product. In the event of contact flush with water for 15 minutes. Get medical attention if symptoms develop.

 

SKIN:              Can cause irritation. Prolonged or repeated exposure can cause drying, defatting, and dermatitis. Use neoprene or rubber gloves and apron when handling this product. In the event of contact wash thoroughly with soap and water. Get medical attention is symptoms develop.

 

INHALATION:           Excessive mist or vapors can cause irritation of the respiratory system, coughing and headache.

 

INGESTION:              May produce intestinal, mucous membrane, throat and esophagus irritation with possible damage to vital organs. DO NOT induce vomiting. Get immediate medical attention.

 

IN ALL CASES:          GET PROMPT MEDICAL ATTENTION IF ADVERSE EFFECTS PERSIST

 

PRIMARY ROUTES OF ENTRY:      Skin, eyes, inhalation, ingestion.

 

HYGIENE:      Wash hands and face before eating or drinking. Wash soiled clothing before wearing again if contact occurs.

SECTION 7 – PRECAUTIONS FOR SAFE HANDLING, STORAGE AND USE

 

 

 

SPILLS AND LEAKS:            Eliminate all ignition sources. Contain to prevent loss to the environment. Collect excess material. Absorb residual material with absorbent. Handle as hazardous waste.

 

STORAGE AND HANDLING:           Keep containers tightly closed. Store at ambient temperatures and away from any heat or ignition sources.

 

WASTE DISPOSAL:              Follow the recommendations of local, state and federal regulations.

 

EMPTY CONTAINERS:        Send to a reconditioning firm or return to Wausau Chemical Corporation.

 

SECTION 8 – REGULATORY INFORMATION

 

 

DOT SHIPPING DESCRIPTION:      Combustible Liquid, N.O.S., (Petroleum Distillate), NA1993 PG III

 

LABEL REQUIRED                            NONE

 

The information contained herein is given in good faith, but no warranty, representation, inducement or license of any kind is made, except that the information is accurate to the best of Wausau Chemical Corporation’s knowledge, or is obtained from sources believed by Wausau Chemical Corporation to be reliable and accurate. Wausau Chemical Corporation does not assume any legal responsibility for use or reliance upon the information being furnished. Customers are encouraged to conduct their own tests. Before using any product, read the container label directions as well as the Material Safety Data Sheet.

 

 

 

 

 

 

ND – Not Determined              NA – Not Applicable               NE – Not Established